AUTONET TV

Transmission Service at Muffler & Go in Fenton

Let's talk about transmission service. It can be easy for Fenton drivers to forget about getting their transmission serviced because it doesn't need it very often. It's easier for people in MI to remember to change the engine oil - you know, every 3,000 miles or 5,000 kilometers. But proper transmission servicing keeps your vehicle running smoothly and helps you avoid repairs down the road.

The transmission undergoes a lot of stress. The grit you can see in used transmission fluid is actually bits of metal that wear off the gears in the transmission. In addition to that, the transmission operates at very high temperatures. Usually, it's much higher than engine temperatures. Those high temperatures eventually cause the transmission fluid to start to break down and lose efficiency.

As the fluid gets older, it gets gritty and doesn't lubricate and cool the vehicle transmission as well - leading to even more wear. The fluid can actually get sludgy and plug up the maze of fluid passages inside the transmission. At best, your transmission won't operate smoothly. At worst, it could lead to damage.

When your transmission is running properly, it transfers more power from your engine to the drive wheels and improves fuel economy. That's why it is recommended to change your transmission fluid at regular intervals. Your owner's manual has a schedule for transmission service and, of course, your service advisor at Muffler & Go can tell you what is recommended.

Hot and dusty Fenton area conditions, towing, hauling, stop-and-go driving and jackrabbit starts all begin to increase the load on the transmission and its internal temperature. That means Fenton vehicles with these types of transmission requirements need to change the fluid more often. A good rule of thumb is every 35,000 miles, 55,000 kilometers or two years. If your owner’s manual suggests more frequent intervals or if you're driving under severe service conditions around the Fenton area, you will need to change it more often.

Most Fenton auto service centers (including Muffler & Go) have the ability to perform a transmission service while you wait and the cost is quite reasonable. It's downright cheap when you think about how much a major transmission repair can cost! Our pros at Muffler & Go will know the right type of transmission fluid to use. If it's getting to be time to have your transmission serviced, do your vehicle a favor and have it done.

Muffler & Go
1478 N Leroy St
Fenton, MI 48430
(810) 629-1066
http://www.mufflerandgo.net

Muffler & Go Service for Your Exhaust System

Your vehicle's exhaust system is more than just a tailpipe and a muffler. In fact, it is one of the most complex systems on your vehicle.

The manifold is attached to the vehicle engine. It collects exhaust from the cylinders and directs it into the exhaust pipe. Gaskets seal the connection of the manifold to the engine and to other joints. A cracked or loose manifold or a leaking or damaged gasket can allow dangerous gases to enter the passenger compartment of a vehicle. One of these gases is carbon monoxide, which is colorless, odorless and deadly. For this reason, it is important American Fork residents keep their exhaust system in good repair.

The pipes that connect the various parts of the exhaust system can rust or be damaged by rocks or other road debris. Such damage can cause dangerous gases to leak into the air.

The catalytic converter is the next component of your vehicle exhaust system. It sort of looks like a muffler. Its job is to change dangerous gases into harmless carbon dioxide and water. The catalytic converter doesn't require any regular maintenance, but it can wear out. If it fails, you will need a new catalytic converter to pass an emissions test in MI. Call Muffler & Go at (810) 629-1066 if you suspect a problem with your catalytic converter.

Oxygen sensors in the exhaust pipe monitor the oxygen content of the exhaust. This helps the vehicle engine's computer keep the fuel-to-air mixture at optimal levels.

The muffler is also part of your vehicle exhaust system, but it deals with a different kind of emission. It keeps your vehicle from emitting bad sounds. Mufflers act like finely tuned musical instruments. They create a feedback of sound waves to absorb or decrease the noises made by your engine. Different mufflers can create different sound waves, so you can actually “tune” your car to produce a particular sound, anything from whisper to rumble.

It is important that damaged mufflers be replaced immediately at your Fenton automotive service center, especially if they are leaking. Not only will the extra noise annoy your Fenton neighbors, a leaky muffler could be serious.

The entire exhaust system is attached to your vehicle by hangers and clamps. These fasteners can rust, come loose or break. The components of the exhaust system can get very hot, so when the hangers or clamps fail, these hot components can come into contact with other parts such as wires and hoses. These can melt, causing serious and damage to your vehicle. Good car care requires that you have your exhaust system inspected regularly.

Caring for your vehicle exhaust system at Muffler & Go yields cosmetic benefits like quieting your engine sounds, but also may impact your health and safety. Your life, or the life of a loved one, may actually be on the line.

Muffler & Go
1478 N Leroy St
Fenton, MI 48430
(810) 629-1066
http://www.mufflerandgo.net

In the Hot Seat (Repair and Maintenance of Seat Heaters)

It's chilly outside. You flip on that switch that looks like a picture of a seat with little heat waves rising from it.  You expect soon you'll feel that warmth but… wait! It's not getting warmer.  Oh no, what's wrong with my seat heater? There could be lots of reasons it's not working, and it could be as simple as a fuse or as major as the heating element itself.  But it's something to leave to a pro to diagnose and repair.

Let's say it turns out to be a blown fuse.  Simply replacing the fuse may not fix it because there was a reason the fuse blew in the first place.  It's possible the on-off switch has worn out or corroded.  Perhaps the wiring connection isn't completing the circuit (could be corroded or full of dirt) or the voltage reaching the heating element isn't correct. 

There's a little sensor that keeps track of the seat heater's temperature called the thermistor.  When the seat is hot enough, it will stop the juice from heating it any more.  Sometimes those fail.  But if all of these components are healthy, you may need a new heater element. 

Those seat-heating elements are made up of wires that get sat on.  A lot.  That can put significant strain on them.  Putting something heavy on the seat can break them. Or, if you put your knees on the seat cushion as you're getting something in a rear seat, that can also damage the element.  Sometimes they can be repaired but often they have to be replaced.  And here is where the technician's expertise comes into play.  That heater element is attached to the seat's fabric and replacing it can be tricky.  It also can require disassembling a lot of the seat to access it. 

Seat heaters are a wonderful feature and they make your vehicle oh, so much cozier.  So keep them working and enjoy the warmth!

Muffler & Go
1478 N Leroy St
Fenton, MI 48430
(810) 629-1066
http://www.mufflerandgo.net

Good Timing: Proper Timing Belt Replacement Saves Money for Fenton Drivers

Knowing how their engine works can help Fenton drivers make informed decisions about auto care and prevent repairs to their vehicles. This is especially true when it comes to timing belts.

An engine's power is generated in the cylinders. Inside the cylinder is a piston that moves up and down while the engine is running. Power is generated in a cycle that includes four strokes of the piston. First, the piston drops and a valve at the top of the cylinder opens to let in fuel and air. The piston then rises, which compresses the fuel and air. At this point, the spark plug fires, igniting the fuel and pushing the piston down. This downstroke transfers energy to the engine, which provides the power it needs to run. The piston rises again, and a valve opens to release the exhaust.

All of this movement is orchestrated by a timing belt. The timing belt is so named because it keeps the pistons and valves operating in synch with each other, just as a conductor keeps all of the instruments in an orchestra in time with one another. Thus, the timing belt is critical to the proper operation of your engine.

Not all vehicles in the Fenton area have timing belts. Some have timing chains. A timing chain is more durable and rarely breaks, but timing belts are cheaper, so many use them to save money.

Timing belts wear out and break, so part of preventive maintenance for Fenton drivers is to replace the timing belt on schedule.

The results of failure of a timing belt depend on the type of engine in your vehicle, but they are always inconvenient and can be very costly for Fenton auto owners. If your engine is a non-interference engine and the timing belt breaks, the engine simply stops running. Now that can be an incredibly inconvenient situation depending on where you are driving around Fenton when it breaks, but it won't cause any engine damage. On the other hand, if your vehicle has an interference engine and the timing belt breaks, the valves on your cylinders will actually fall into the path of the pistons. Then things start getting chewed up by the motion of the engine and it will cost thousands of dollars to get everything sorted out again. Compounding the problem is that there aren't any warning signs before a timing belt breaks. A visual inspection of the belt is difficult also. In some vehicles, parts of the belt may be visible, but most vehicles hide the belt under a cover.

The timing belt doesn't even have to break to cause major engine damage. If it slips, even one notch, the result could be engine damage with repair costs in the thousands of dollars.

Our only car care option is to simply replace the timing belt periodically. You can check your owner's manual to find out how often your timing belt should be replaced. Many vehicles need a replacement at 60,000 miles (100,000 kilometers), but the recommended replacement mileage could be as high as 90,000 or 100,000 miles (145,000 to 160,000 kilometers). If your owner's manual recommends replacement at 60,000 miles (100,000 kilometers), however, don't wait until 65,000 miles (105,000 kilometers) to get it done. Remember what you're risking.

Replacing a timing belt is not a cheap part of preventive maintenance for Fenton vehicle owners. The belt is usually difficult to get to and often requires removal of some of the engine accessories. The cost of the replacement, however, is a lot less than what the repairs may cost if the timing belt fails.

For more auto advice on timing belts and other engine components, you can always consult with your service advisor at Muffler & Go. When it comes to car care, ignorance is not bliss. It can end up costing you in a big way.

Muffler & Go
1478 N Leroy St
Fenton, MI 48430
(810) 629-1066
http://www.mufflerandgo.net